1、工人應接受防護教育，每天班前主要點關注施工操作要點，加強質量意識教育。每道工序施工前，應向工人進行詳細的技能交底。
1. Workers should first receive protection education, pay attention to the key points of construction operation before work every day, and strengthen quality awareness education. Before the construction of each process, detailed skill disclosure shall be made to the workers.
2、工程所需的所有材料和設備需要有合格證或材質證明，各種證明要掛牌登記，并與實物核對。沒有這份文件，檢查或建設可能會被拒絕。如有疑問，應進行檢查判斷，經檢查合格后方可使用。
2. All materials and equipment required for the project shall be provided with certificates or material certificates. Various certificates shall be listed and registered and checked with the physical objects. Without this document, inspection or construction may be rejected. In case of doubt, it shall be checked and judged, and can be used only after passing the inspection.
3、彩鋼板裝置應平直，板面不應有施工殘留物和污垢。檐口應在一條直線上，不應有未經處理的錯鉆。
3. The color steel plate device shall be straight, and the plate surface shall be free of construction residues and dirt. The cornice shall be in a straight line, and there shall be no untreated wrong drilling.
4、運輸、堆積和吊裝禁止彩板變形和油漆脫落。
4. During transportation, stacking and hoisting, the color plate shall not be deformed and the paint shall not fall off.
5、山墻泛洪層頂部高250mm，沿屋面坡度高10mm、15mm。其次，用M6膨脹螺栓固定防水板與凹槽的連接處，并用密封膠密封外露的膨脹螺栓；與車頂板的接頭用自攻螺釘固定在車頂板支架上，防水板與車頂板的接頭用長擋水帶防水。
5. The top of the gable flood layer is 250mm high, and the height along the roof slope is 10mm and 15mm. Secondly, fix the joint between waterproof board and groove with M6 expansion bolt, and seal the exposed expansion bolt with sealant; The joint with the roof panel is fixed on the roof panel support with self tapping screws, and the joint between the waterproof board and the roof panel is waterproof with a long water retaining belt.
6、形成彩鋼板后，涂層和鍍層上不應有可見的裂紋、剝落和劃痕。
6. After the color steel plate is formed, there shall be no visible cracks, peeling and scratches on the coating and coating.
7、彩鋼板、泛水板和角板應固定牢固，防腐涂料和密封材料應鋪設完好。
7. Color steel plate, flashing plate and corner plate shall be fixed firmly, and anti-corrosion coating and sealing materials shall be laid in good condition.
8、彩鋼板形成后，外觀應干凈，不應有明顯的凹凸和皺紋。
8. After the color steel plate is formed, the appearance shall be clean without obvious concave convex and wrinkles.
9、項目經理部及其他作業力量應嚴格按照批準的技術文件施工，不得隨意變更。現場技術人員和質量檢查員工有權對性能狀況進行檢查，并及時糾正違反既定方法的施工方法。
9. The project management department and other operation forces shall construct in strict accordance with the approved technical documents and shall not change at will. On site technicians and quality inspection staff have the right to inspect the performance status and correct the construction methods that violate the established methods in time.
10、如發現彩鋼板原施工工藝有缺陷，現場技術負責人提出修改意見，經原批準部分批準后，以技能聯系單形式告知變更。
10. If the original construction process of color steel plate is found to be defective, the on-site technical director shall put forward modification opinions, and inform the change in the form of skill contact sheet after being approved by the original approval part.
11、施工人員可對批準的技能和方法提出合理建議，經原批準部分批準后，用聯系單告知變更。
11. The construction personnel can put forward reasonable suggestions on the approved skills and methods, and inform the change with the contact list after being approved by the original approval part.
The above is the knowledge brought to you today. Jinan color steel plank house has focused on the industry for many years and continuously provides users with valuable content. Please continue to pay attention to us for more content: http://www.nbcmds.com
